Boiler Feedwater Pump

Boiler feedwater pump
A boiler feedwater pumpis a specific type of pump used to pump feedwater into a steam boiler. The water may be freshly supplied
or returning condensate produced as a result of the condensation of the steam produced by the boiler. These pumps are normally high
pressure units that take suction from a condensate return system and can be of the centrifugal pump type or positive displacement
type.
Contents
Construction and operation
Failure of mechanical seal
Steam-powered pumps
Duplex steam pump
Model Pumps
See also
References
Construction and operation

Feedwater pumps range in size up to many horsepower and the electric motor is usually separated from the pump body by some form
of mechanical coupling. Large industrial condensate pumps may also serve as the feedwater pump. In either case, to force the water
into the boiler, the pump must generate sufficient pressure to overcome the steam pressure developed by the boiler. This is usually
accomplished through the use of a centrifugal pump.Another common form of feedwater pumps run constantly and are provided with
a minimum flow device to stop overpressuring the pump on low flows. The minimum flow usually returns to the tank or deaerator
.
Failure of mechanical seal

Mechanical seals of boiler feedwater pumps often show signs of electrical corrosion. The relative movement between the sliding ring
and the stationary ring provokes static charging which is not diverted due to the very low conductivity of the boiler water below one
micro-Siemens per cm [μS/cm]. Within short periods of operation – in some cases only a few hundred operational hours – pieces
having the size of finger tips break off from the sliding and/or the stationary ring and cause rapid increases in leakage current.
.[1]
Diamond-coated (DLC) mechanical seals avoid this problem and extend durability remarkably
Steam-powered pumps
Steam locomotives and the steam engines used on ships and stationary applications such as power plants also require feedwater
pumps. In this situation, though, the pump was often powered using a small steam engine that ran using the steam produced by the
boiler. A means had to be provided, of course, to put the initial charge of water into the boiler (before steam power was available to
operate the steam-powered feedwater pump). The pump was often a positive displacement pump that had steam valves and cylinders
at one end and feedwater cylinders at the other end; no crankshaft was required.
Duplex steam pump

A duplex steam pump has two sets of steam and water cylinders. They are not
physically connected but the steam valves on the first pump are operated by the
movement of the second pump's piston rod, and vice versa. The result is that there
[2]
are no "dead spots" and the pump is always self-starting.
Model Pumps
SIMPLEX-MODEL 281
DUPLEX-MODEL 282
DUAL-MODEL 282A
TRIPLEX-MODEL 283A[3]
See also
Boiler feedwater
Injector Weir feedwater pump
References
1. Diamond-coated (DLC) seals in 27.000h endurance test,(http://www.hfm.tugraz.at/en/references/pumpen/diamantbe
schichtete-gleitringdichtungen-fuer-kesselspeisepumpen.html)
Technical University of Graz
2. "Duplex Pump (from Internet Glossary of Pumps)"(http://www.animatedsoftware.com/pumpglos/duplexpu.htm).
Animatedsoftware.com. Retrieved 2012-04-22.
3. "Boiler Feed Model Pumps"(http://www.callaghanpump.com/wp-content/uploads/2016/12/Aurora280Bulletin.pdf)
(PDF).
Retrieved from "https://en.wikipedia.org/w/index.php?title=Boiler_feedwater_pump&oldid=833817800

"
This page was last edited on 2 April 2018, at 15:40(UTC).
Text is available under theCreative Commons Attribution-ShareAlike License ; additional terms may apply. By using this
site, you agree to the Terms of Use and Privacy Policy. Wikipedia® is a registered trademark of theWikimedia
Foundation, Inc., a non-profit organization.

Boiler Feedwater Pump

Uploaded by

Boiler Feedwater Pump

Uploaded by

Boiler feedwater pump

Construction and operation

Failure of mechanical seal

Duplex steam pump

Retrieved from "https://en.wikipedia.org/w/index.php?title=Boiler_feedwater_pump&oldid=833817800

This page was last edited on 2 April 2018, at 15:40(UTC).

You might also like