ES–58 2AZ-FE ENGINE CONTROL SYSTEM – SFI SYSTEM

DIAGNOSTIC TROUBLE CODE CHART

HINT:
Parameters listed in the chart may be different than your
readings depending on the type of instrument and other
factors.
If any DTCs are displayed during a check mode DTC check,
check the circuit for the DTCs listed in the table below. For
details of each DTC, refer to the page indicated.

DTC No. Detection Item Trouble Areas MIL Memory See page
P0010 Camshaft Position - Open or short in Oil Comes on DTC stored ES-62
"A" Actuator Circuit Control Valve (OCV)
(Bank 1) circuit
ES - OCV
- ECM
P0011 Camshaft Position - Valve timing Comes on DTC stored ES-66
"A" - Timing Over- - OCV
Advanced or System - OCV filter
Performance (Bank - Camshaft timing
1) gear assembly
- ECM
P0012 Camshaft Position - Same as DTC Comes on DTC stored ES-66
"A" - Timing Over- P0011
Retarded (Bank 1)
P0016 Crankshaft Position - - Mechanical system Comes on DTC stored ES-72
Camshaft Position (Timing chain has
Correlation (Bank 1 jumped tooth or chain
Sensor A) stretched)
- ECM
P0031 Oxygen (A/F) Sensor - Open in Air-Fuel Comes on DTC stored ES-74
Heater Control Circuit Ratio (A/F) sensor
Low (Bank 1 Sensor heater circuit
1) - A/F sensor heater
(sensor 1)
- Integration relay
(EFI MAIN relay)
- ECM
P0032 Oxygen (A/F) Sensor - Short in A/F sensor Comes on DTC stored ES-74
Heater Control Circuit heater circuit
High (Bank 1 Sensor - A/F sensor heater
1) (sensor 1)
- Integration relay
(EFI MAIN relay)
- ECM
P0037 Oxygen Sensor - Open in Heated Comes on DTC stored ES-80
Heater Control Circuit Oxygen (HO2)
Low (Bank 1 Sensor sensor heater circuit
2) - HO2 sensor heater
(sensor 2)
- Integration relay
(EFI MAIN relay)
- ECM
P0038 Oxygen Sensor - Short in HO2 sensor Comes on DTC stored ES-80
Heater Control Circuit heater circuit
High (Bank 1 Sensor - HO2 sensor heater
2) (sensor 2)
- Integration relay
(EFI MAIN relay)
- ECM
 2AZ-FE ENGINE CONTROL SYSTEM – SFI SYSTEM ES–59

DTC No. Detection Item Trouble Areas MIL Memory See page
P0100 Mass or Volume Air - Open or short in Comes on DTC stored ES-86
Flow Circuit Mass Air Flow (MAF)
meter circuit
- MAF meter
- ECM
P0101 Mass Air Flow Circuit - MAF meter Comes on DTC stored ES-93
Range / Performance - Air induction system
Problem - PCV hose
connections
P0102 Mass or Volume Air - Open or short in Comes on DTC stored ES-86
Flow Circuit Low MAF meter circuit
Input - MAF meter
- ECM
P0103 Mass or Volume Air - Open or short in Comes on DTC stored ES-86
Flow Circuit High
Input
MAF meter circuit
- MAF meter
ES
- ECM
P0110 Intake Air - Open or short in Comes on DTC stored ES-96
Temperature Circuit Intake Air
Malfunction Temperature (IAT)
sensor circuit
- IAT sensor (built into
MAF meter)
- ECM
P0111 Intake Air - Mass air flow meter Comes on DTC stored ES-102
Temperature Sensor assembly
Gradient Too High
P0112 Intake Air - Short in IAT sensor Comes on DTC stored ES-96
Temperature Circuit circuit
Low Input - IAT sensor (built into
MAF meter)
- ECM
P0113 Intake Air - Open in IAT sensor Comes on DTC stored ES-96
Temperature Circuit circuit
High Input - IAT sensor (built into
MAF meter)
- ECM
P0115 Engine Coolant - Open or short in Comes on DTC stored ES-105
Temperature Circuit Engine Coolant
Malfunction Temperature (ECT)
sensor circuit
- ECT sensor
- ECM
P0116 Engine Coolant - Thermostat Comes on DTC stored ES-111
Temperature Circuit - ECT sensor
Range / Performance
Problem
P0117 Engine Coolant - Short in ECT sensor Comes on DTC stored ES-105
Temperature Circuit circuit
Low Input - ECT sensor
- ECM
P0118 Engine Coolant - Open in ECT sensor Comes on DTC stored ES-105
Temperature Circuit circuit
High Input - ECT sensor
- ECM
P0120 Throttle Pedal - Throttle Position Comes on DTC stored ES-114
Position Sensor / (TP) sensor (built into
Switch "A" Circuit throttle body)
Malfunction - ECM
P0121 Throttle / Pedal - TP sensor (built into Comes on DTC stored ES-121
Position Sensor / throttle body)
Switch "A" Circuit
Range / Performance
Problem
 ES–60 2AZ-FE ENGINE CONTROL SYSTEM – SFI SYSTEM

DTC No. Detection Item Trouble Areas MIL Memory See page
P0122 Throttle / Pedal - TP sensor (built into Comes on DTC stored ES-114
Position Sensor / throttle body)
Switch "A" Circuit - Short in VTA1 circuit
Low Input - Open in VC circuit
- ECM
P0123 Throttle / Pedal - TP sensor (built into Comes on DTC stored ES-114
Position Sensor / throttle body)
Switch "A" Circuit - Open in VTA1 circuit
High Input - Open in E2 circuit
- Short between VC
and VTA1 circuits
- ECM
P0125 Insufficient Coolant - Cooling system Comes on DTC stored ES-123
Temperature for - ECT sensor

ES Closed Loop Fuel

Control
- Thermostat

P0128 Coolant Thermostat - Thermostat Comes on DTC stored ES-126

(Coolant - Cooling system
Temperature Below - ECT sensor
Thermostat - ECM
Regulating
Temperature)
P0136 Oxygen Sensor - Open or short in Comes on DTC stored ES-129
Circuit Malfunction HO2 sensor (sensor
(Bank 1 Sensor 2) 2) circuit
- HO2 sensor (sensor
2)
- HO2 sensor heater
(sensor 2)
- Air-Fuel Ratio (A/F)
sensor (sensor 1)
- Integration relay
(EFI MAIN relay)
- Gas leakage from
exhaust system
P0137 Oxygen Sensor - Open in HO2 sensor Comes on DTC stored ES-129
Circuit Low Voltage (sensor 2) circuit
(Bank 1 Sensor 2) - HO2 sensor (sensor
2)
- HO2 sensor heater
(sensor 2)
- Integration relay
(EFI MAIN relay)
- Gas leakage from
exhaust system
P0138 Oxygen Sensor - Short in HO2 sensor Comes on DTC stored ES-129
Circuit High Voltage (sensor 2) circuit
(Bank 1 Sensor 2) - HO2 sensor (sensor
2)
- ECM internal circuit
malfunction
P0141 Oxygen Sensor - Open or short in Comes on DTC stored ES-80
Heater Circuit HO2 sensor heater
Malfunction (Bank 1 circuit
Sensor 2) - HO2 sensor heater
(sensor 2)
- Integration relay
(EFI MAIN relay)
- ECM
 2AZ-FE ENGINE CONTROL SYSTEM – SFI SYSTEM ES–61

DTC No. Detection Item Trouble Areas MIL Memory See page
P0171 System Too Lean - Air induction system Comes on DTC stored ES-147
(Bank 1) - Injector blockage
- MAF meter
- ECT sensor
- Fuel pressure
- Gas leakage from
exhaust system
- Open or short in A/F
sensor (sensor 1)
circuit
- A/F sensor (sensor
1)
- A/F sensor heater
(sensor 1)
- Integration relay
(EFI MAIN relay)
- A/F sensor heater
ES
and EFI MAIN relay
circuits
- PCV hose
connections
- PCV valve and hose
- ECM
P0172 System Too Rich - Injector leakage or Comes on DTC stored ES-147
(Bank 1) blockage
- MAF meter
- ECT sensor
- Ignition system
- Fuel pressure
- Gas leakage from
exhaust system
- Open or short in A/F
sensor (sensor 1)
circuit
- A/F sensor (sensor
1)
- A/F sensor heater
(sensor 1)
- Integration relay
(EFI MAIN relay)
- A/F sensor heater
and EFI MAIN relay
circuits
- ECM
P0220 Throttle / Pedal - TP sensor (built into Comes on DTC stored ES-114
Position Sensor / throttle body)
Switch "B" Circuit - ECM
P0222 Throttle / Pedal - TP sensor (built into Comes on DTC stored ES-114
Position Sensor / throttle body)
Switch "B" Circuit - Short in VTA2 circuit
Low Input - Open in VC circuit
- ECM
P0223 Throttle / Pedal - TP sensor (built into Comes on DTC stored ES-114
Position Sensor / throttle body)
Switch "B" Circuit - Open in VTA2 circuit
High Input - Open in E2 circuit
- Short between VC
and VTA2 circuits
- ECM
 ES–62 2AZ-FE ENGINE CONTROL SYSTEM – SFI SYSTEM

DTC No. Detection Item Trouble Areas MIL Memory See page
P0300 Random / Multiple - Open or short in Comes on/Blinks* DTC stored ES-156
Cylinder Misfire engine wire harness
Detected - Connector
connection
- Vacuum hose
connection
- Ignition system
- Injector
- Fuel pressure
- MAF meter
- ECT sensor
- Compression
pressure
- Valve clearance
- Valve timing
ES - PCV valve and hose
- PCV hose
connections
- Air induction system
- ECM
P0301 Cylinder 1 Misfire - Same as DTC Comes on/Blinks* DTC stored ES-156
Detected P0300
P0302 Cylinder 2 Misfire - Same as DTC Comes on/Blinks* DTC stored ES-156
Detected P0300
P0303 Cylinder 3 Misfire - Same as DTC Comes on/Blinks* DTC stored ES-156
Detected P0300
P0304 Cylinder 4 Misfire - Same as DTC Comes on/Blinks* DTC stored ES-156
Detected P0300
P0327 Knock Sensor 1 - Short in knock Comes on DTC stored ES-168
Circuit Low Input sensor circuit
(Bank 1 or Single - Knock sensor
Sensor) - ECM
P0328 Knock Sensor 1 - Open in knock Comes on DTC stored ES-168
Circuit High Input sensor circuit
(Bank 1 or Single - Knock sensor
Sensor) - ECM
P0335 Crankshaft Position - Open or short in Comes on DTC stored ES-172
Sensor "A" Circuit Crankshaft Position
(CKP) sensor circuit
- CKP sensor
- CKP sensor plate
- ECM
P0339 Crankshaft Position - Same as DTC - DTC stored ES-172
Sensor "A" Circuit P0335
Intermittent
P0340 Camshaft Position - Open or short in Comes on DTC stored ES-178
Sensor "A" Circuit Camshaft Position
(Bank 1 or Single (CMP) sensor circuit
Sensor) - CMP sensor
- Camshaft
- Jumped tooth of
timing chain
- ECM
P0351 Ignition Coil "A" - Ignition system Comes on DTC stored ES-183
Primary / Secondary - Open or short in
Circuit IGF1 or IGT circuit (1
to 4) between ignition
coil with igniter and
ECM
- No. 1 to No. 4
ignition coils with
igniters
- ECM
 2AZ-FE ENGINE CONTROL SYSTEM – SFI SYSTEM ES–63

DTC No. Detection Item Trouble Areas MIL Memory See page
P0352 Ignition Coil "B" - Same as DTC Comes on DTC stored ES-183
Primary / Secondary P0351
Circuit
P0353 Ignition Coil "C" - Same as DTC Comes on DTC stored ES-183
Primary / Secondary P0351
Circuit
P0354 Ignition Coil "D" - Same as DTC Comes on DTC stored ES-183
Primary / Secondary P0351
Circuit
P0420 Catalyst System - Front exhaust pipe Comes on DTC stored ES-191
Efficiency Below (with Three-Way
Threshold (Bank 1) Catalytic Converter)
- Gas leakage from
exhaust system
- A/F sensor (sensor
1)
ES
- HO2 sensor (sensor
2)
P043E Evaporative Emission - Canister pump Comes on DTC stored ES-198
System Reference module (Reference
Orifice Clog Up orifice, leak detection
pump, vent valve)
- Connector/wire
harness (Canister
pump module - ECM)
- EVAP system hose
(pipe from air inlet
port to canister pump
module, canister
filter, fuel tank vent
hose)
- ECM
P043F Evaporative Emission - Same as DTC Comes on DTC stored ES-198
System Reference P043E
Orifice High Flow
P0441 Evaporative Emission - Purge VSV Comes on DTC stored ES-203
Control System - Connector/wire
Incorrect Purge Flow harness (Purge VSV
- ECM)
- Canister pump
module
- Leakage from EVAP
system
- Leakage from EVAP
line (Purge VSV -
Intake manifold)
- ECM
P0450 Evaporative Emission - Canister pump Comes on DTC stored ES-210
Control System module
Pressure Sensor / - EVAP system hose
Switch (pipe from air inlet
port to canister pump
module, canister
filter, fuel tank vent
hose)
- ECM
 ES–64 2AZ-FE ENGINE CONTROL SYSTEM – SFI SYSTEM

DTC No. Detection Item Trouble Areas MIL Memory See page
P0451 Evaporative Emission - Canister pump Comes on DTC stored ES-210
Control System module
Pressure Sensor - Connector/wire
Range / Performance harness (Canister
pump module - ECM)
- EVAP system hose
(pipe from air inlet
port to canister pump
module, canister
filter, fuel tank vent
hose)
- ECM
P0452 Evaporative Emission - Same as DTC Comes on DTC stored ES-210
Control System P0451
Pressure Sensor /
ES Switch Low Input
P0453 Evaporative Emission - Same as DTC Comes on DTC stored ES-210
Control System P0451
Pressure Sensor /
Switch High Input
P0455 Evaporative Emission - Fuel cap (loose) Comes on DTC stored ES-220
Control System Leak - Leakage from EVAP
Detected (Gross line (Canister - Fuel
Leak) tank)
- Leakage from EVAP
line (Purge VSV -
Canister)
- Canister pump
module
- Leakage from fuel
tank
- Leakage from
canister
P0456 Evaporative Emission - Same as DTC Comes on DTC stored ES-220
Control System Leak P0455
Detected (Very Small
Leak)
P0500 Vehicle Speed - Open or short in Comes on DTC stored ES-224
Sensor "A" speed signal circuit
- Vehicle speed
sensor
- Combination meter
- ECM
- Skid control ECU
P0504 Brake Switch "A" / "B" - Short in stop light - DTC stored ES-229
Correlation switch signal circuit
- STOP fuse
- IGN fuse
- Stop light switch
- ECM
P0505 Idle Control System - ETCS (Electronic Comes on DTC stored ES-233
Malfunction Throttle Control
System)
- Air induction system
- PCV hose
connections
- ECM
 2AZ-FE ENGINE CONTROL SYSTEM – SFI SYSTEM ES–65

DTC No. Detection Item Trouble Areas MIL Memory See page
P050A Cold Start Idle Air - Throttle body Comes on DTC stored ES-237
Control System assembly
Performance - MAF meter
- Air induction system
- PCV hose
connections
- VVT system
- Air cleaner filter
element
- ECM
P050B Cold Start Ignition - Same as DTC Comes on DTC stored ES-237
Timing Performance P050A
P0516 Battery Temperature - Battery current - DTC stored ES-243
Sensor Circuit Low sensor
- Short in battery
current sensor ES
- ECM
P0517 Battery Temperature - Battery current - DTC stored ES-243
Sensor Circuit High sensor
- Open in battery
current sensor
- ECM
P0560 System Voltage - Open in back up Comes on DTC stored ES-245
power source circuit
- Battery
- Battery terminals
- EFI MAIN fuse
- ECM
P0604 Internal Control - ECM Comes on DTC stored ES-249
Module Random
Access Memory
(RAM) Error
P0606 ECM / PCM - ECM Comes on DTC stored ES-249
Processor
P0607 Control Module - ECM Comes on DTC stored ES-249
Performance
P0617 Starter Relay Circuit - Park/Neutral Comes on DTC stored ES-251
High Position (PNP) switch
- ST relay circuit
- Ignition switch
- ECM
P0630 VIN not Programmed - ECM Comes on DTC stored ES-256
or Mismatch - ECM /
PCM
P0657 Actuator Supply - ECM Comes on DTC stored ES-249
Voltage Circuit /
Open
P0724 Brake Switch "B" - Short in stop light Comes on DTC stored ES-258
Circuit High switch circuit
- Stop light switch
- ECM
P1550 Battery Current - Short in battery - DTC stored ES-261
Sensor Circuit current sensor circuit
- Battery current
sensor
- ECM
P1551 Battery Current - Short in battery - DTC stored ES-261
Sensor Circuit Low current sensor circuit
- Battery current
sensor
- ECM
 ES–66 2AZ-FE ENGINE CONTROL SYSTEM – SFI SYSTEM

DTC No. Detection Item Trouble Areas MIL Memory See page
P1552 Battery Current - Short in battery - DTC stored ES-261
Sensor Circuit High current sensor circuit
- Battery current
sensor
- ECM
P1602 Deterioration of - Battery - DTC stored ES-264
Battery - ECM back-up power
source circuit
P2102 Throttle Actuator - Open in throttle Comes on DTC stored ES-265
Control Motor Circuit actuator circuit
Low - Throttle actuator
- ECM
P2103 Throttle Actuator - Short in throttle Comes on DTC stored ES-265
Control Motor Circuit actuator circuit
ES High - Throttle actuator
- Throttle valve
- Throttle body
assembly
- ECM
P2111 Throttle Actuator - Throttle actuator Comes on DTC stored ES-269
Control System - - Throttle body
Stuck Open assembly
- Throttle valve
P2112 Throttle Actuator - Same as DTC Comes on DTC stored ES-269
Control System - P2111
Stuck Closed
P2118 Throttle Actuator - Open in ETCS Comes on DTC stored ES-272
Control Motor Current power source circuit
Range / Performance - Battery
- Battery terminals
- ETCS fuse
- ECM
P2119 Throttle Actuator - ETCS Comes on DTC stored ES-279
Control Throttle Body - ECM
Range / Performance
P2120 Throttle / Pedal - Accelerator Pedal Comes on DTC stored ES-282
Position Sensor / Position (APP)
Switch "D" Circuit sensor
- ECM
P2121 Throttle / Pedal - APP sensor Comes on DTC stored ES-289
Position Sensor / - ECM
Switch "D" Circuit
Range / Performance
P2122 Throttle / Pedal - APP sensor Comes on DTC stored ES-282
Position Sensor / - Open in VCP1
Switch "D" Circuit circuit
Low Input - Open or ground
short in VPA circuit
- ECM
P2123 Throttle / Pedal - APP sensor Comes on DTC stored ES-282
Position Sensor / - Open in EPA circuit
Switch "D" Circuit - ECM
High Input
P2125 Throttle / Pedal - APP sensor Comes on DTC stored ES-282
Position Sensor / - ECM
Switch "E" Circuit
P2127 Throttle / Pedal - APP sensor Comes on DTC stored ES-282
Position Sensor / - Open in VCP2
Switch "E" Circuit circuit
Low Input - Open or ground
short in VPA2 circuit
- ECM
 2AZ-FE ENGINE CONTROL SYSTEM – SFI SYSTEM ES–67

DTC No. Detection Item Trouble Areas MIL Memory See page
P2128 Throttle / Pedal - APP sensor Comes on DTC stored ES-282
Position Sensor / - Open in EPA2
Switch "E" Circuit circuit
High Input - ECM
P2135 Throttle / Pedal - Short between Comes on DTC stored ES-114
Position Sensor / VTA1 and VTA2
Switch "A" / "B" circuits
Voltage Correlation - TP sensor (built into
throttle body)
- ECM
P2138 Throttle / Pedal - Short between VPA Comes on DTC stored ES-282
Position Sensor / and VPA2 circuits
Switch "D" / "E" - APP sensor
Voltage Correlation - ECM
P2195 Oxygen (A/F) Sensor
Signal Stuck Lean
- Open or short in A/F
sensor (sensor 1)
Comes on DTC stored ES-292 ES
(Bank 1 Sensor 1) circuit
- A/F sensor (sensor
1)
- A/F sensor heater
(sensor 1)
- Integration relay
(EFI MAIN relay)
- A/F sensor heater
and EFI MAIN relay
circuits
- ECM
P2196 Oxygen (A/F) Sensor - Same as DTC Comes on DTC stored ES-292
Signal Stuck Rich P2195
(Bank 1 Sensor 1)
P2238 Oxygen (A/F) Sensor - Open or short in A/F Comes on DTC stored ES-306
Pumping Current sensor (sensor 1)
Circuit Low (Bank 1 circuit
Sensor 1) - A/F sensor (sensor
1)
- A/F sensor heater
(sensor 1)
- Integration relay
(EFI MAIN relay)
- A/F sensor heater
and EFI MAIN relay
circuits
- ECM
P2239 Oxygen (A/F) Sensor - Same as DTC Comes on DTC stored ES-306
Pumping Current P2238
Circuit High (Bank 1
Sensor 1)
P2252 Oxygen (A/F) Sensor - Same as DTC Comes on DTC stored ES-306
Reference Ground P2238
Circuit Low (Bank 1
Sensor 1)
P2253 Oxygen (A/F) Sensor - Same as DTC Comes on DTC stored ES-306
Reference Ground P2238
Circuit High (Bank 1
Sensor 1)
 ES–68 2AZ-FE ENGINE CONTROL SYSTEM – SFI SYSTEM

DTC No. Detection Item Trouble Areas MIL Memory See page
P2401 Evaporative Emission - Canister pump Comes on DTC stored ES-312
Leak Detection Pump module (Reference
Stuck OFF orifice, leak detection
pump, vent valve)
- Connector/wire
harness (Canister
pump module - ECM)
- EVAP system hose
(pipe from air inlet
port to canister pump
module, canister
filter, fuel tank vent
hose)
- ECM
P2402 Evaporative Emission - Same as DTC Comes on DTC stored ES-312
ES Leak Detection Pump
Stuck ON
P2401

P2419 Evaporative Emission - Canister pump Comes on DTC stored ES-318

System Switching module (Reference
Valve Control Circuit orifice, leak detection
Low pump, vent valve)
- Connector/wire
harness (Canister
pump module - ECM)
- EVAP system hose
(pipe from air inlet
port to canister pump
module, canister
filter, fuel tank vent
hose)
- ECM
P2420 Evaporative Emission - Canister pump Comes on DTC stored ES-318
System Switching module (Reference
Valve Control Circuit orifice, leak detection
High pump, vent valve)
- Connector/wire
harness (Canister
pump module - ECM)
- ECM
P2610 ECM / PCM Internal - ECM Comes on DTC stored ES-324
Engine Off Timer
Performance
P2A00 A/F Sensor Circuit - Open or short in A/F Comes on DTC stored ES-326
Slow Response sensor circuit
(Bank 1 Sensor 1) - A/F sensor
- ECM

HINT:
*: MIL flashes when a catalyst damaged misfire is detected.